'Gesell's Automotive Service'

Transmission Service

July 22nd, 2010 by gesells

Let’s talk about transmission service. It can be easy to forget about getting your transmission serviced because it doesn’t need it very often. It’s easy to remember to change the engine oil – you know, every 3,000 miles or 5,000 kilometers. But proper transmission servicing keeps your car running smoothly and helps you avoid costly repairs down the road.

The transmission undergoes a lot of stress. The grit you see in used transmission fluid is actually bits of metal that wear off the gears in the transmission. In addition to that, the transmission operates at very high temperatures. Usually it’s 100 to 150 degrees higher than engine temperatures. Those high temperatures eventually cause the transmission fluid to start to break down and loose efficiency.

As the fluid gets older, it gets gritty and doesn’t lubricate and cool the transmission as well – leading to even more wear. The fluid can actually get sludgy and plug up the maze of fluid passages inside the transmission. At best, your transmission won’t operate smoothly. At worse, it could lead to costly damage.

When your transmission is running properly, it transfers more power from your engine to the drive wheels, and improves fuel economy. That’s why manufacturers recommend changing your transmission fluid at regular intervals. Your owner’s manual has a schedule for transmission service and, of course, your service center can tell you what the manufacturer recommends.

Hot and dusty conditions; towing, hauling, stop and go conditions and jack rabbit starts all increase the load on the transmission and its internal temperature. That means you need to change the fluid more often. A good rule of thumb is every 35,000 miles, 55,000 kilometers or two years. If your manufacturer suggests more frequent intervals or if you’re driving under severe service conditions, you will need to change it more often.

Most service centers have the ability to perform a transmission service while you wait and the cost is quite reasonable. It’s downright cheap when you think about how much a major transmission repair can cost! Your service technician will know the right type of transmission fluid to use. If it’s getting to be time to have your transmission serviced, do your car a favor and have it done. If not this time, then on your next service stop.

Posted in Transmission | No Comments »

WI Balance: Wheel Balancing and Tire Rotation

July 16th, 2010 by gesells

Everyone in the Oconomowoc area wants our tires to last as long as possible. Two ways to maximize tire life are wheel balancing and tire rotation.

When wheels are out of balance, they wobble a bit. That makes the tires wear in a cupping pattern. And they vibrate. To fix this, your service technician at Gesell’s Automotive Service puts weights on your wheels to balance them out. If a front wheel is out of balance you’ll feel it in the steering wheel. If it’s a rear wheel you’ll feel it through your seat.

That brings us to tire rotation. The front tires on a car wear out more quickly than the rear tires. As they push through turns from Oconomowoc to Sullivan, the shoulders of the front tires wear down. So rotating front and rear tires allows them to all wear at about the same rate over the life of the tire.

Proper tire inflation will also help your tires last longer. Under-inflated tires wear excessively on the shoulder and may even overheat. This could cause tire damage or a blow out. Over-inflated tires wear to fast in the middle.

Four wheel drive trucks and SUV’s tend to wear their tires more unevenly so rotation is even more important with them. Give us a call to get our recommendation on your minivan, suv.

See your owner’s manual or ask your service technician at Gesell’s Automotive Service for your recommended tire rotation schedule. It’s usually every 5,000 to 8,000 miles.

Tires cost a lot and they are one of the most critical safety components on your vehicle. Take care of them and they’ll take care of you.

Gesell’s Automotive Service
N6335 Hwy F
Oconomowoc, WI 53066
262-593-2715

Posted in Tires and Wheels | No Comments »

My Dealer In Oconomowoc Closed: What Do I Do?

July 7th, 2010 by gesells

New car dealership closings are all over the news. Nearly 800 Chrysler dealerships canceled. About 1,100 GM dealers’ contracts will not be renewed after October 2010. And record numbers are just shutting down because they aren’t selling enough cars and trucks to stay in business.

It’s estimated that some 40,000 dealership service bays could be taken out of service in the next year or so.

Of course, this is a tragedy for those who work at our local Oconomowoc dealerships and the owners that risk losing much of their life’s work. Our Oconomowoc communities will lose some of our best corporate citizens. Think of all the youth sports team, service clubs and Oconomowoc community events that have been sponsored by our local new car dealers.

One question we hear a lot at AutoNetTV is, ‘Who will service my car?’ Oconomowoc folks are concerned that they will not get the care and attention they need. They’re wondering where they will find trained technicians in the Oconomowoc area. Will they be able to get quality replacement parts for their vehicles?

Fortunately, the Oconomowoc automotive aftermarket is ready to fill the need. As one of over 200,000 independent service and repair facilities in North America, Gesell’s Automotive Service is here to help. Gesell’s Automotive Service has been the backbone of the automotive service and repair industry for Oconomowoc and will continue to provide this vital role.

Gesell’s Automotive Service has the latest diagnostic and repair equipment, access to parts and repair databases, and a commitment to the highest standards of technician training. The reality is that our independent service center in Oconomowoc is ready to service all your vehicle’s needs – and we always have been. We don’t have to ’step up’ to the task – we’re ready now.

Many consumers in Oconomowoc have known this about the local Oconomowoc independent service and repair industry and have used it for all their non-warranty work. And they have enjoyed greater convenience and have saved quite a bit of money along the way: The average independent service and repair center in Oconomowoc costs 34% less than the dealership.

And of course, Gesell’s Automotive Service has access to the very same replacement parts as the dealership as well as a selection of superior parts for greater reliability and enhanced performance. And we can source parts that may help with a tight budget as well.

So in the midst of uncertainty surrounding dealership closings, know you can turn to your local Oconomowoc independent service center to take care of your family’s safety and to keep your vehicles performing well. You’ll save some money too. And that’s good news in these times.

Gesell’s Automotive Service
N6335 Hwy F
Oconomowoc, WI 53066
262-593-2715

Posted in Service Standards | No Comments »

Wheel Balancing

July 2nd, 2010 by gesells

So you love our job, and your family life is great: You have achieved balance. But can you the same for your wheels? You can tell if your tires are out of balance by vibrations at higher speeds. If one of the front tires is out, you feel the vibration in the steering wheel. If it’s a back tire, you’ll feel the vibration in your seat.

Tires and wheels are pretty heavy. When a tire is mounted on a wheel, it is usually not perfectly balanced. So the tire technician will spin the tire on a machine to determine where it’s too heavy. He will then place weights on the wheels in strategic locations to balance it out. When a tire is out of balance, it actually bounces down the road instead of rolling smoothly. Since the average size tire rotates at about 850 revolutions per minute at 60 MPH, it is actually slamming into the pavement 14 times a second. That’s where you get your vibration.

Most people are surprised at how smoothly their car rides after balancing all four wheels.

Most high-quality tires hold their balance pretty well. They just get out of balance gradually with normal wear and tear. If you suddenly feel a vibration, it is probably because you lost a wheel balancing weight along the way. Definitely get a balance if you feel a vibration, change your rims or have a flat repaired. Putting off a needed balance job leads to excessive tire wear, wear to your shocks, struts, steering and suspension parts. wheel balancing not only improves your ride and handling, but also can save you some big repair bills and possibly an accident. Additionally, you will get better gas mileage.

Some people have their tires balanced at every rotation. Others do it every other time. Check your owners’ manual for your requirements, or ask your technician. Doing thus will put you on the path to mechanical wheel balance

Posted in Tires and Wheels | No Comments »

Clean Fuel Makes a Happy Engine In Oconomowoc WI

June 25th, 2010 by gesells

If the fuel system in your minivan, suv is dirty, you will be wasting gas and losing performance as you drive around Oconomowoc WI.

Unless you drive a vintage car, you have fuel injectors. They need to be properly maintained. That is why your owner’s manual has a schedule for cleaning your fuel injectors and other parts of your fuel system.

Your service technician at Gesell’s Automotive Service has the tools and chemicals to do the job right. Gesell’s Automotive Service uses a process that gives your car a deep, professional fuel system cleaning. The particles, gum and varnish that build up in your fuel system are removed so that it can run cleanly and efficiently.

After a professional fuel system cleaning, you’ll notice more power, better gas mileage and reduced exhaust emissions. AutoNetTV strongly recommends you follow your manufacturer’s fuel system cleaning service recommendations to keep your vehicle running strong.

It’s expensive to replace a fuel injector that’s been damaged by neglect. Check with your service technician at Gesell’s Automotive Service and see when your car is scheduled for a fuel system cleaning.

Posted in Fuel System | No Comments »

Higher Mileage Service Intervals

June 16th, 2010 by gesells

The government mandates a lot of equipment on cars: emission devices and control computers; safety equipment like airbags; and crash worthiness requirements. All of this is great for the motoring public, but it does add quite a bit to the price of a new car.

Because new cars are more expensive, WI drivers are using their old cars longer. The average car is now over nine years old. 68% of vehicles on the road have more than 75,000 miles/120,000 kilometers. As cars age, their performance drops, they have difficulty idling for long periods and are more sensitive to weather extremes. Fortunately today’s cars are up to the challenge – but they need a little help to keep on going.

Some owner’s manuals don’t specify service requirements at higher mileage. That doesn’t mean it doesn’t have to be done. In fact, it’s more important than ever to stay on top of routine maintenance for cars with more than 120,000 miles/190,000 kilometers. Just extend regular service intervals out: for instance a service that’s recommended every 24,000 miles/38,000 kilometers should be performed at 24,000 mi/38,000 km; 48,000 mi/77,000 km; 72,000mi/116,000 km, 96,000 mi/154,000 km; and on and on.

Because of the additional stress older engines experience, the severe service maintenance schedule may be more appropriate than the regular schedule. Watch for leaks – seals and gaskets dry out over time and do not hold the fluids as well as they used to. It is also time to make sure you have a good technician like the pros at Gesell’s Automotive Service in Oconomowoc. There are some services and replacements that are scheduled after you put some clicks on the odometer, like timing belts, valve train adjustments, suspension, anti-lock brake service, air bags, etc. And unexpected repairs down the road are just par for the course.

Check for unusual sounds, smells or the way your car feels. These could be hints that trouble is brewing. Better to catch it early before it turns into a costly repair. Regular wash and wax will help maintain your car’s appearance. One of the things you can do to really help your high mileage vehicle is to begin using high mileage formulation fluids. There are special engine oils, coolants, and transmission and power steering fluids that are formulated for cars that have a higher mileage.

High mileage oil is designed to condition seals and gaskets, reduce wear and avoid premature burn off. Older engines are dirtier inside – and dirty engines contaminate their oil faster. High mileage oil has special additives that clean the engine, removing sludge deposits over time. The result is less stress on the engine, better fuel economy and excellent wear protection.

Studies have even shown that using high mileage fluids early will actually prevent some of the problems of high kilometer vehicles. So once you hit around 50,000 mi/80,000 km, consider stepping up to high mileage formulations. The fluids cost a bit more than standard fluids because of the additional additives, but they can be worth their weight in gold in terms of preventing repair costs down the road.

It does cost more to properly maintain a higher mileage vehicle – but it’s much cheaper than a new car payment!

Posted in Fuel System | No Comments »

Risk of Extended Oil Change Intervals

June 10th, 2010 by gesells

Nothing in your engine workers harder than your oil. With hundreds of moving parts, and thousands of explosions every minute, it’s no wonder that engine oil needs to be changed frequently!

You’ve probably heard the old rule of thumb: Change your oil every 3,000 miles/ 5,000 kilometers or 3 months, whichever comes first. But some car manufacturers have introduced extended oil change intervals. They figure that a modern vehicle driven under the right conditions can go for 5,000 miles/8000 kilometers or more between an oil change.

The key phrase here is “under the right conditions”. If you look at your owner’s manual, you’ll see two different maintenance schedules: one for “normal” driving conditions and one for “Severe Service”. Severe service driving conditions include stop and go, short trips, towing, hauling, hot, cold, and dusty driving. That’s why at AutoNetTV we often refer you to the severe service schedule in your owners’ manual, because, for most of us WI car owners, that’s the way we use our vehicles in everyday life.

Recently, four of the largest auto manufacturers in the world have extended engine warranty coverage for engine damage caused by oil sludge resulting from longer oil change intervals. They found that real-world conditions require more frequent oil changes than the 7,500mi/12,000 km interval they were recommending. They subsequently recommended more frequent oil change intervals and proof of timely oil changes in order to qualify for the extended warranty.

Oil sludge is the culprit. Sludge is oil that has turned to a thick, jelly-like consistency. Sludge can block passages in the engine, preventing oil from lubricating vital engine parts. Parts wear more quickly and may fail prematurely.

Sludge is caused by several factors. The first one is simply – time. The engine oil is contaminated by exhaust gas that eventually leads to sludge. That is where the recommendation to change your oil at least every three months comes from. Sludge can also come from oil that gets contaminated by water from normal condensation. A few minutes of driving at WI freeway speeds allows the oil to heat up enough for the water to evaporate. The problem is we often run errands or take other short trips that don’t allow the engine to warm up enough for the water to evaporate. This is especially true in winter. Sludge also forms when the engine gets too hot, causing the oil to breakdown. Stop and go summer driving, towing and hauling are all prime conditions for creating harmful sludge. And every engine has hot spots that create sludge.

Given all of these factors, estimating when to change your oil is pretty complicated. A couple of manufacturers have computer programs built into their vehicles that record the number of cold starts, how many times the cylinders fire, engine temperature and other factors. From that, the computer estimates when you should change your oil and flashes a warning. But what if you do not have a vehicle with this feature? How do you know when to change your oil? We’re not sure you really can. Which is why it is better to be safe than sorry. 3,000 mi/5,000 km or three months – whichever comes first – talk with a service advisor at Gesell’s Automotive Service in Oconomowoc and see if that’s a good recommendation for the way you drive.

Posted in Maintenance | No Comments »

Coolant Antifreeze Service

June 2nd, 2010 by gesells

You may know that most automotive failures are tire related, but do you know the second most common cause for vehicle failure? Nope, it’s not teenagers. It is the coolant system. But, if you take good care of your coolant system, it will take good care of you.

A car’s engine creates a lot of heat – so much heat, that if it is not properly cooled, the engine can lock up, resulting in massive damage and repair bills. But when everything is working right, your engine operates at the proper temperature and all is well. Without antifreeze in your cooling system, the water could freeze and cause engine damage. This could be very expensive, not to mention inconvenient.

The right mix of water and antifreeze protects the engine against damage from freezing and overheating. Antifreeze also protects the coolant system against corrosion that could cause the system to fail. The thing to remember is this: coolant system failure is very common, but it is also very easy to prevent. Service technicians at Gesell’s Automotive Service can check the manufacturers’ recommendations, and tell you when the coolant needs to be changed. See http://www.gesellsauto.com/contact_us_19.html. They can also perform a coolant system service.

Even the best antifreeze cannot completely protect the coolant system from harmful deposits forever. The anti-corrosion additives are used up over time, so the coolant must be replaced. A coolant service cleans out the system and replaces the old fluid with fresh coolant. A coolant system service is a low-cost way to protect against major engine repairs down the road. Prevention is the key. Be sure to watch out for the two main warning signs: if your temperature gauge is in the “hot” zone or if you get a message warning you to check your coolant. If you take a look under the hood, you will see the coolant overflow bottle. You can see there are lines that indicate the proper level of coolant … if your engine is cold – or if it is hot.

You can add water or antifreeze to that bottle yourself, but be careful. First, you never want to open the radiator pressure cap. The steam could severely burn you. Second, try to get to your Dousman or Sullivan auto service center immediately if your coolant is low. If that is not possible, follow the directions in your owner’s manual. Third, remember that you need a proper mixture of water and antifreeze, or you will damage your engine. If you make an emergency addition to your cooling system, follow-up with your service center where they can make necessary corrections. Fourth, not all cars use the same type of antifreeze. You will need to check your owner’s manual to make sure you use the right kind. Mixing antifreeze types or using the wrong kind of antifreeze may void the manufacturers warranty on your cooling system. If you’re not sure, ask your Oconomowoc area service technician for guidance.

Posted in Cooling System | No Comments »

Oconomowoc Exhaust And Emissions Service

May 27th, 2010 by gesells

Sometimes when we talk about exhaust service in Oconomowoc, we think about exhaust pipes and mufflers. And if you can see smoke, or if it’s too loud. But, exhaust service at a place like Gesell’s Automotive Service is really a lot more comprehensive these days.

For example, in the U.S., the federal government mandated catalytic converters for all cars in Oconomowoc in 1976 and on-board emission control computers in 1990. WI and federal emissions requirements have forced manufacturers to come up with much more sophisticated ways to comply with environmental regulations. Cars sold in Canada follow the same guidelines.

So, exhaust service has really become exhaust and emissions service. High-tech computer-controlled emissions devices are now a big part of that. And because it’s so sophisticated, your vehicle manufacturer recommends having your emission system checked out by a qualified technician, like the ones we have at Gesell’s Automotive Service, regularly to make sure everything’s working right – which is usually every six months or 6,000 miles.

If your ‘check engine light’ comes on while you are driving around the Oconomowoc area, especially if it’s flashing, then you need to get your car looked at right away. Chances are it’s an emission related problem. You might have exhaust or emissions trouble if your car is hard to start, runs rough, or if it’s noisy or smoking.

So let’s review the exhaust system. Everything starts with the exhaust manifold. That’s the part that attaches to the engine and collects the exhaust from the cylinders and directs it into the exhaust pipe.

The exhaust gaskets help seal the connection with the manifold and other joints along the way. Now, if the manifold is cracked or loose, or a gasket is leaking, then dangerous gases could escape into the passenger compartment, where you ride. Carbon monoxide can be deadly, so it’s important that your exhaust system doesn’t leak.

The exhaust pipes connect the various components. They can rust or be damaged by a rock, so they need to be inspected periodically.

Next comes the catalytic converter. This part actually looks like a muffler. It changes chemicals that are dangerous to your health, and to the local WI environment, into harmless carbon dioxide and water. Now it doesn’t require any maintenance itself. But eventually they wear out. If it has, you’ll probably find out when your car fails an emissions inspection.

Now the muffler. Its main job is to quiet engine noises. Mufflers work by either absorbing or baffling sound. And you can actually customize your car’s sound with different mufflers – which is pretty cool because you can change the look of your car, and the way it sounds.

Rusted or road-damaged mufflers can actually leak and they need to be replaced right away. The exhaust system is attached to the car by a series of hangers and clamps that hold the system in place. And when these hangers come loose or break then hot exhaust components can touch and melt wires, hoses and lines. Just think of the damage a hot curling iron can do – but worse. It’s not good to have that waving around.

And finally, we end at the tailpipe. Appropriate name. This is the final outlet for the exhaust. And one other component is the oxygen sensor. It monitors the oxygen content of the exhaust so the engine-control computer can adjust the fuel-to-air mix to keep the car running right.

We hope this hasn’t been too ‘exhausting’ of a discussion, but these things impact everything from life and death safety due to exhaust leaks, to just fine-tuning the sound of your ride. And talk with your service advisor at Gesell’s Automotive Service if you feel you need any of these items inspected on your vehicle, because a quick look can sure save a lot of pain down the road.

Auto Tips Videos provided for Gesell’s Automotive Service by AutoNetTV

Posted in Exhaust | No Comments »

Before You Leave Oconomowoc, Get A Trip Inspection

May 21st, 2010 by gesells

You know, at Gesell’s Automotive Service we get a lot of people asking about how to prepare their car for a trip. That’s a big deal. You could be driving through mountains and deserts in some pretty lonely areas outside of Oconomowoc so you may be anxious to know that the car is up to the task and won’t leave you stranded.

You really do need to plan ahead for a major road trip – there are a lot of things to get ready. Where should you start? You could start with the tires. Look them over for tread wear and check to see that they are properly inflated. Take a quick test drive around Oconomowoc to see if you can feel any vibrations: are the wheels are in balance? Is the car tracking straight? Is the alignment ok?

Come in and see us for trip inspection.

Gesell’s Automotive Service
N6335 Hwy F
Oconomowoc, WI 53066
262-593-2715

The next thing is a full service oil change to make sure all of your fluids are topped off and you have fresh oil for the trip. And if your car has over 75,000 miles, you may consider putting in the high-mileage formulation to clean harmful sludge deposits in the engine. You may also need a new PCV valve and an engine air filter.

How about your transmission and brakes? Have you had your transmission and brakes inspected in the last six months?

How are your wiper blades? There’s nothing like not being able to get rid of the bug juice on a long road trip away from Oconomowoc.

Check your owners’ manual for any other recommended service and have Gesell’s Automotive Service do the multi-point inspection before you head out.

Consider also having the coolant system serviced – you want to stay within the manufacturer’s recommendations. If you’re towing a trailer you’ll want to be keep in mind that you’ll be going a long way under severe conditions.

A lot of folks overlook severe conditions like towing, or summer heat, or driving on dirt roads. Plan ahead for your next road trip – we want you to get there and back.